Yet it is perfect. No, weve never needed to do any needle valve maintanence. Bill confuses me sometimes too. I and two others donate sap to our county park district to boil down. He said he was processing between 18-20 of sap per hr. Man I wish I could have Bill on video chat! Based on 403 gm / liter of sucrose at 35 Brix, that comes out 250 grams or only 2/3 of available sugar at start. Hi Gordie Surprise your maple-loving family and friends! Please consider submitting your own how-to advice through the write for us link in the About Us tab above. I have run straight hot water thru and the water drain flows freely. The mix ratio is 1.1 ounces to 1 gallon of permeate. I saw on line there are 400gpd membranes and housings available. One option is to build your own reserves osmosis set up using filters like those that are used for water purification and are available at many hardware stores. Seriously. At the end of every season, we run 5-10 gallons of permeate through the system, then we remove the filters from their casings and mark where each filter was in the system (so we can change their position each year, to hopefully give them a longer life) Then we put them in a ziplock bag and store them in the refrigerator until the next sugar season. I got a food grade 55 gallon barrel, but too late to have time to clean it out, so for next year thats the goal. WebTotal 9584 products from sugar free substitute for maple syrup Manufactures & Suppliers Assuming your sap is gravity feed to the pump, is there any suggested distance above the pump for the container of sap to be for this to work? tanks of propane. We set this little baby up right in the kitchen every night, if were collecting the permeate. According to Leader Evaporator, it is a process through which a semi-permeable membrane is used to separate water from salt, sugar, minerals, and other impurities. In other words, water is fed through a system that removes impurities and leaves you with just pure H20. Its was 2% to start with. We particularly love the UV filter in the Sugar Cube for food safety reasons. What a huge time saver. Maple syrup is made by boiling maple sap to evaporate most of the water until we are left with 66% sugar. Thank you. Thanks again for the help. If you continue to use this site we will assume that you are happy with it. The only problem I run into is getting the pump primed and pulling in the sap, but a little elevation does the trick! Thanks and happy sugaring!! Ive had this bookmarked for a while and finally made mine. Likewise, as much as we love sitting outside by the evaporator with friends, there comes a point where 18 hours of boiling each weekend can feel cumbersome; getting to syrup faster is not a bad thing. Great questions. I need to get me some Sweet Maple! I run my RO at between 90 and 100 psi on my pressure gauge, and split my flow at 50% RO water coming out to 50% concentrate to get these numbers. We run permeate through the systema full 5-gallon bucket worthevery time were done using it for the day. I have an option on a good refurbished RO for $1000 that can cope with up to 1000 taps. What is the function of the 5 micron filter? when you say running a bucket of permeate ., Im assuming you mean going through the bucket using the system the same way you use it to go through your SAP. So we persoanlly choose to boil our sap with propane. Im pretty sure sugar maple trees would grow here, but in zone 8, would they make syrup? Just follow their directions and it will work for you.. It really sets your mind at ease reading your sugar content out of the tree, then after the RO, ( concentrate) and then measuring your RO water (permeate) its fun to see how your sugar % almost doubles one pass through the system for your concentrate, and the RO water measures at almost zero. I realized I had things set up all wrong. Thank you very much for this system. Its kind of you to share all this information with the back yarders. And great question about what we run it at! This means less time monitoring the evaporator and, importantly, less wood needed to boil and make our syrup. And Id love to hear about your alternations if you find great success! After filtering when do I need to process. Found your website while investigating maple syrup processing, found your RO system and proceeded to order all pieces you you have linked, now waiting for one more piece. Volunteers boil it down and the park sells it. Hi Michelle, Yes, Laurent is right, if you JUST want to measure the sugar content of your SAP, you can save money by getting a refractometer that only measures on the lower end of the scale like this one: https://amzn.to/2X0Wb08 BUT I personally want one refractometer that can measure everything I need to know sugar content in sap as well as syrup. I have quadruple-checked everything and cant seem to find the problem. If we can order it on Amazon and have it on our front porch in two days, with zero shipping costs, well its almost as fast as driving to Lowes. What happens if you use fewer membranes? Works great. Hi Michelle, My primary limitation is sap storage. Im not understanding every item youre referring to. I have additional questions regarding cleaning and storing the filters : Any addivce? WebHeat allows maple syrup to develop the characteristic color and flavor that make it so desirable. I looked into RO years ago but never realized one could build one. Im a wife to my high school sweetheart, mom to four daughters, and ardent fan of all things maple-flavored. I think it now costs me almost $30 per gallon in LP to make. Mark & Colleen Falardeau, backyard sugarmakers who built this RO system, explain, It cost us roughly $300 to make our RO and it takes sap from 2-3% sugar content to 7-8% in one pass! Do I need to replace the filters ya think? The next two weekends I recirculated the sap at 80-90 psi and the difference was incredible. I have about 80 red maples some are huge and some are younger. I am hoping to make one before this years season! For you, it is more about the experience than the production. We have 110 taps and process roughly 5 gallons of sap through the RO every 45 minutes.). The authors homemade PVC hangers for collecting syrup. I think yours is probably the best Ive seen for the amount of taps one can do. Im doing a pretty small operation, but getting just large enough that my fire cant keep up, so wondering if I can cut a few corners and come up with something for closer to $200. For instance, if I planted a maple, how long before I could tap it? And were left with pure, cool permeate but well talk more about the permeate and how we like to use it in another post, later this season. They said they could see the difference. Ive enjoyed your posts about it immensely and Im amazed at how much fuel it takes to make just one pint, so this little gadget that Bill put together must be a wonderful time- and fuel-saver. We rinse them with every use, by running a bucket of permeate through the filters, and we give them a thorough cleaning the end of every season. I have never run an RO system and am not quite sure how to run it. Another unique benefit of the Sugar Cube is that it adds an Ultraviolet (UV) filter to the system as well. And I have huge respect for Bill and for YOU, since youre here. WebTotal 9584 products from sugar free substitute for maple syrup Manufactures & Suppliers The amazing beauty of this The line with the needle valve is the line that carries the ROd sap that then is boiled. We live in nowhere-ville, so traveling to Lowes is quite a trek. But after every single use we run 5 gallons worth of permeate back through, to flush the filters. (Id love to keep it all.) I would boil this down in less than 3 hours in my 24 pan. It will cut your fuel costs in half, if not more. Making maple syrup is a labor of love, especially for a hobby sugaring operation with small equipment. lets just say you would just look at all those parts and cry and call for your daughter or husband, who are the true engineers in the family. We use cookies to ensure that we give you the best experience on our website. Lastly, are you doing anything special to store the filter in between seasons? Of course, no matter what you use for fuel, cuddling with a barn cat while you watch the sap boil makes everything a little more puuurfect. Look into a refractometer. You could also reach in and remove large pieces of debris with a slotted spoon. You are very welcome Jill just 4 years ago I was someone like you and needed all the help I could get. Jason. Afterall, we all wanna save on fuel, no matter where were get it, can I get an amen? Recently, new membrane processes have been developed to concentrate maple sap to ultra-high Brix reaching up to 40 Brix. I have completed the building of my RO kit and am awaiting sap season here in minnesota. Hi Michelle, I was setting up my RO. 7. If you are prone to fits of unrestrained enthusiasm, such as I am, you may want to add capacity by adding additional RO membranes in series. It Does it make sense that the flow from both the permeate and the clean water is similar? All said and done, I ended up with about 2 gallons of syrup, using 2.5 tanks of propane and finishing in the kitchen. Please let us know how it works for you! When you can limit the boiling process by running it through reverse osmosis (RO), the syrup does not darken nearly as much and the flavor is much more mild and enjoyable. Looks like we will need a bigger system next year. Im a New England homesteader and the author of Sweet Maple. Thanks again for sharing all this info.. Great to hear from you Gordie! Look up a group called the Vancouver Island Sapsuckers. Do the filters NEED to be kept in the fridge? So glad youre finding it helpful. On that unit I used all 3/8 lines and 3/8 fittings and so am excited to get this up and running. Apple Bitters, Organic Maple Syrup and Garnished with Maple Infused Bacon. Their reverse osmosis system helps to produce high quality maple syrup. (Sorry, bad pun. I had a few doubters when I said I was going to do this. I will share your story with Bill (cause hes never on my blog :)). The easiest way to do this is to make PVC vessels. I saved a incredible amount of time and firewood.. Hi Jason, Your RO filter looks fantastic. We live in the Deep South. When doing a final flush and clean, do you use any Citric acid, membrane soap or neutralizing agent? Thanks for doing the legwork to find the correct tubing. What a great question. Cost then was quite high to buy. That top will not spin unless the line is cut. Hi, Im Michelle. I put my sap into a 50 gallon drum and recirculate for the day. Wanna know how we even do some natural ro for FREE? . I have had a couple of people say it does, Hi Mackenzie, This is a common question but honestly I have yet to ever talk to one person who says that ROd syrup tastes different than non-ROd syrup. I got a lot of wet. Thanks so much for your information. You will glue on an end cap on one end and then install a threaded cap on the other. How does that compare to my costs last year? This filter eliminates bacteria and yeast in your sap, leaving you with sap concentrate that stores longer. Visit our affiliate disclosure page to learn more. I think I may try to rig up a smaller system than yours, by eliminating 1 or 2 of the RO filters and maybe running the sap thru twice. Every detail you need to knowand how to get every piece and partis all broken down for you right here. The views expressed by authors on this site are based on their experiences only; Homestead-How To in no way provides any warranty, expressed or implied, toward the content of these articles. I MAY be able to talk hubby into it though He was wondering if there is upkeep/maintenence needed on the needle valve? Hi Dick. a maple syrup producer records the amount. But for now, our little homemade one gets the job done. My regular syrup hydrometer just wont measure the small amounts of sugar If you have any ideas on which one to buy that would help. How do you clean this system? Id like to try building a RO system for my 70 tap operation and Im wondering what the difference is between the one your husband built and a RO system for under your sink for tap water? Electric skillet ran from 1:40 to 4:50 pm at about 1,200 kw and removed 1.0 gallons Required fields are marked *. Hi Jim, I have never have run my sap through more than once, but I know people who do. even read about storing the filters in permeate. Im up to $541 ordering the recommended parts on Amazon and am attempting to reduce the cost. Last year, I made about 1 gallon of sap and used 4(!!!) Try Amazon Prime 30-Day Free Trialby clicking through this link. This article goes over how to use reverse osmosis in a sugaring operation using a few different methods. Hi Lucas, glad you solved your problem before I even saw your comment. the system is working flawlessly now. He wound up making twice as much syrup using almost half the amount of propane: I made 2 gallons of syrup this year, using 2.5 tanks of propane. WebMaking Maple Syrup - Easy Homemade Reverse Osmosis System for Water Removal from Maple Sap Rudi Jones 4.11K subscribers Subscribe 3.9K views 10 months ago As an Amazon Affiliate, we earn commission on qualified purchases. My questions are. She is a Founder and Editor of Homestead How-To and also blogs about her family's homestead life at The Happy Hive. I love making syrup, and baking with syrup, and writing about maple syrup, but I do not know how to build something like this awesome Reverse Osmosis set up that we have. I had different results than most users that Ive read, but the results are exceptional. Our family lives on 14 wooded acres, and we cut and store a lot of wood. Its all Bills work. The other item you listed, 1/4 polyethylene tubing (25 of it) item #814305, model #98584, Is correct, but technically it has an OD of 3/8 and the ID is 1/4. Every evening during the season, when were done RO-ing for the day, we simply run the RO one more cycle, using permeate instead of sap. Funny you think we have a sap house boy wouldnt THAT be nice!? Im sure youll notice lots of time savings this year! Theyre the exact same filters. Thanks so much. of pure water an hour. The 1/4 ID has a 3/8 OD. Yep, we often run it through twice. Thats why we own this one: https://amzn.to/2X0X9cM Both are fine choices, depending on what you want. I have not been able to remove much water just passing the sap thru the system. By morning I would have 30 40 gallons of sap to boil down. At the end of the season we store the filters in a ziploc bag in the fridge until next season. You can try a 0-10% refractometer you can find these for 20-30 bucks on Amazon! Wed love to hear from you! If you where to increase your pressure would you be able to process more sap and hour or are you restricted by your filters to your pressure? Michelle, fyi my issue was a bad membrane. 0; . Im a retired guy who has made between 10 and 15 gallons of syrup annually using an open pan and LP gas as a heat source. So weve actually never tried to run it in an unheated area. Separation by reverse osmosis Up to two-thirds of the water in maple sap can be separated by using reverse osmosis before the boiling process, which will 1. Attached is a pdf of the components you'll need. I have no particular relationship with the suppliers or brands listed, they just happened to be Click on the image below to pin this post. Super weird that this is the first time anyones noticed these #s not working, but you are the second person in just a few days time who has noticed this, so Im betting Bills right. A backyard sugarmaker in New England, and author of Sweet Maple. Free samples of maple products and maple baked Sounds crazy, but Ive talked to too many folks who do this to not believe em. You need to check out this article where I describe Bills system in detail: https://soulyrested.com/2020/03/02/how-to-make-syrup-using-pumps-for-collecting-sap/ Hope that helps! That is really clever! Listing Good Luckthis a great little unit and has saved me so many hours of boiling. Also, is it normal for the system to not continuously flow into the filter housing? Its rather simple, its rather small, but its totally huge on savings. This is the 3rd year of tapping. But first, let me applaud you. The pump is available for sale on line; I linked to the one we use above. The amount of wood we were using was starting to feel counter-productive. EZ-FLO 0.170-in ID x 150-ft Polyethylene Tubing Item #879275Model #98632. Enjoy your sugar season!! I noticed in your post on 2/15/19 to Christine, that you ID the red line as the sap line, when I think that it is the waste water from what I can tell by both your diagram and the actual photo of your set up. I would run the RO over night and extract about 7 gals. Hi Mark, Its all Greek to me, but Bill said thats just his perference but you definitely can choose something else. True story. Our experience was that after 10% you could begin to see a slight difference in taste, and by 12% to 14% it was no longer a product that we wanted to sell, so youre right that 1 or 2 passes with this RO will not vary in taste. I got it all through amazon, eventually (after returns for having the wrong size fittings thank you Kohls). Build Your Own Maple Syrup Reverse Osmosis Rig GardenFork 196K subscribers 652 45K views 2 years ago How to make a DIY reverse osmosis system for just goes to show attention to detail is vital. Lowes is a 45 minute drive at best and the prices were higher and if I made those mistakes yikes!! The whole point of boiling sap is to evaporate water and be left with a thick, sugary maple syrup. If youd like to see how the professional sugarmakers do RO, this reverse osmosis unit right here is amazing. and3.5-4 after I ran mine thru the RO system. . thanks again for the great info.. Gordie, Im so glad youre enjoying your RO & Im glad our directions helped with your build! It took about a week of rinsing with water to get the smell from the pvc primer and glue to go away. Do the limbs of the trees hold up well? Thanks for that suggestion. Its just reversed. All this and so much more is explained in Sweet Maple. a five gallon bucket at around 7%. Put them into two separate buckets and voila, you can cut the water content of your sap by up to 50%. Reverse Osmosis is a process typically used in water purification. When that bucket is half full I pull it and start the next bucket. She lives on a small homestead in Vermont with her husband, two children, and a rambunctious border collie. Costs for home producers are relatively high Thanks for your info. When you flush with permeate to rinse filters are you doing this under pressure with the needle valve nearly closed or with the valve wide open? Hi Bill, Im not sure Im understanding your question but the 50% is the increase in sugar content. If youre more of a visual person and would like to get a peak of our RO system at work, youll want to hop over and watch my youtube video. Keep them from extreme heat and freezing and they will be safely stored until next season. I also list, below, every single item Bill bought to build our system. I can confirm all your answers have been great and correct I have built 4 of these units now,and everyone loves them. Any thoughts or comments? This post contains affiliate links & I may receive commissions for purchases made through links in this post. It does have an ID of 3/8, but it should have an OD of 3/8. My goal for this was to have it run when Im not actively monitoring it and want to save the pump. Otherwise, read on. We use the 150 gpd filters. Then at the end of the season, we store the membranes in ziploc baggies in the fridge. This is only to remove any sediment, bugs, or twigs from the sap. Approaches to syrup production. Thanks for your suggestion about the elevation, Aaron, and I will pass your appreciation on to Bill. But if we could get some of the water out of the sap before it goes into the evaporator. Read thisarticle right here. You definitely want to build it in series. The sap will be filtered again later, after it's boiled. Ive been tapping for the last 20 years, 60-100 trees and need to cut down may evaporator/firewood time at 73. Happy boiling! I just received all the parts today and hope to assemble over the holidays. A pre-made RO system like the Sugar Cube can cost up to $500, but if you are going to use it over the course of many years, youll save that much in firewood and your time to make it worth it. Is your sap house heated s0 that the RO machine doesnt freeze or do you somehow keep it from freezing or doesnt it matter if it freezes? Wanna know how to build your own Reverse Osmosis system for making maple syrup? Looking forward to next year. Cook zucchinis, garlic cloves and rosemary for 4 mins until beginning to colour. Hope you have a fantastic sugar season! 5. If you're a minimalist you can forego this step and plug the motors directly into extension cords. But I like the convenience of having an off/o Save my name, email, and website in this browser for the next time I comment. ROd to about 5% then electric skilleted to 21 ounces of 35% for a quart jar. It seems they both work well, just the way they are plumbed. Funding for this project was made possible by the U.S. Department of Agricultures (USDA) Agricultural Marketing Service through grant AM170100XXXXG167, Alan. Im wanting to do up to 200-300 trees this year. Keep them standing upright and give them a little shake to make sure all the air bubbles are out. If you have a refractometer (I explain that tool here: https://soulyrested.com/2020/01/25/how-to-make-syrup-what-tools-do-you-need/), you should measure your brix (sugar content) before and after the RO. Like you said in your post I bought most of my stuff on Amazon, and it was not hard to put together, especially now everyone can see your instructions. I think thats a great idea to build it now, during your down time and then its all ready and waiting for you next syrup season! Then checked the permeate and it was 0.3%. I guess looking at the elbows and paying attention to the image of your setup is crucial to a correct build. Have you done any upgrades to your present listed system at all? Do you clean the system during the season and if so what do you use? I have tried using only one membrane filter, hooking up each of the 4 membranes solo still, it wont pump through. Hi Larry. If you have a new parts list that you used, with the corrected item #s and details, that would be helpful. Otherwise the sugar concentration will lead to bacteria-filled sap in no time. Im a New England homesteader and the author of, heres a facebook live video showing how it works, one of the Top 20 Must-Read Homesteading Blogs of 2018, read more about my camera and even purchase your own here, One tip that will save you hundreds on your DIY maple syrup, https://soulyrested.com/2017/04/12/make-maple-syrup-step-step/, https://soulyrested.com/snag-free-ebooks/, https://soulyrested.com/2020/01/25/how-to-make-syrup-what-tools-do-you-need/, https://soulyrested.com/2020/03/02/how-to-make-syrup-using-pumps-for-collecting-sap/, Chocolate Chip Cookies made with fresh flour, 8 Things You Can Make (Better) Yourself (S4, E10). formId: '608a538fe8b3a8e1e4d62a1d', Ill use a 5 gal bucket for permeate (for cleaning system) and waste the rest on the ground. Thanks Bill and Michelle sharing you drawing on a RO system. Hi Marlowe. Or if I just used two but passed everything through twice? There is one more thing I need to get and that is a more sensitive hydrometer. btw, if you dont already have Amazon Prime, I highly recommend it. I think I was confused by the drawing compared to the picture and the term permeate kept messing me up. I may try that this year.. The filters in the RO serve the same purpose as they would if you were using them in a water purifying system they take out the impurities in the sap, leaving only water (permeate) except in this case the impurities are the sugars, which of course is exactly what we want to keep. If youre like me. 6. Mount the RO membrane housing horizontally to the Unistrut channels about 3 inches above the motor using the Unistrut pipe clamps.There are two The Sugar cube is an RO system built into a compact ammo box with handles so that you can move it around as needed. Im weighing up the cost of building a larger unit like the smallest commercial unit which sells for around $1450. You do need the needle valve. Suggested uses (non-specific recipe uses): Use birch syrup to enhance sandwiches, using a hearty bread like sourdough or peasant bread makes the experience even better. Ray Ingham is a hobby sugarmaker inHuntington, Vermont. Me? Syrup is made by removing water from the sap, so that only the sugar remains. . Carrie Williams Howe is an educational leader by day and an aspiring homesteader by night and weekend. That would still account for only 60 of the missing 130 grams. My concentrate was sound 4%. This kit is indeed awesome! I meant to ask, Wouldnt the less expensive 115V direct plug booster pump (i.e., not needing a transformer) be a simpler and effective option? I want to thank you and your husband again for sharing.. How wonderful!!! I wish we had tap-able trees here, but I doubt that oaks are on the list! Especially the maple section because we have been making 11 years on Prince Edward Island. Tony Hansen How to Turn Maple Sap into Maple-Syrup. I love my Nikon; you canread more about my camera and even purchase your own here. It will take more water out of the sap, I was just happy to get it down to half. Heather Gilson, whose family has about 50 taps in their backyard on any given year, explains, My husband built one last year and man was it a time saver for us!! Just wanted to thank you for the great instructions on building an RO. The links were particularly useful, and i made good use of them.. As we speak, I am three gallons of concentrate to the good, and am planning double my taps. On top of that, severe weather changes, or drastic weather fronts can cause sap to run freezing nights while ideal are definitely not necessary to successfully tap a tree. I hope you LOVE your RO and all the money it saves you! Rev O did 0.03 kwh per gallon water removed I get this a lot and just realized I need to update the above post to explain this to folks! how do you wash your ro system after each use ? Hi Michael, No need to apologize I could never build one of these myself. Souly Rested lists all of the supplies you need to make your RO system and where to get them, and estimates run that these supplies cost about $300 (give or take). I think Im removing maybe 10% of the water and am running at 70psi. (And heres a facebook live video showing how it works.) I am going to give it a go. icon below: window.fd('form', { ), If you wanna read more about why we ro,go here. I am intrigued by this system and would like to attempt to build one however I have a few questions as I have no experience with ROs. Feed your Family: How to Start a Vegetable Garden from Scratch, this set of instructions from Souly Rested, Sugar Cube Reverse Osmosis System from Vermont Evaporator Company, How to Prepare your Vegetable Garden for Winter (Fall Garden Checklist). the system is working flawlessly now. If I use a cheaper RV pump that can get up to 60 PSI would I run into trouble? But I can absolutely answer your second question. Hi Michelle, To build a reverse osmosis set up of your ownand seriously slash your fuel costsyoull need a piece of plywood, or something similar, for mounting everything, and youll need the following items, which are all pictured below as well, in the order theyre listed. Happy sugaring! This is working really well and Im obviously removing half of the water (that takes about 45 minutes). That way, by the time the sap has run through all 4 filters youve refined it down to a much higher sugar content than when you started. How do you adjust the pressure; is that what the needle valve is for? Skillet ran from 1:40 to 4:50 pm at about 1,200 kw and removed 1.0 gallons Required are... Removing maybe 10 % of the season we store the membranes in ziploc baggies in the?... Attempting to reduce the cost of building a larger unit like the commercial. Minutes. ) and it was 0.3 % filters in a sugaring operation using few. ( UV ) filter to the image of your sap by up to 40 Brix never run an RO after! Skillet ran from 1:40 to 4:50 pm at about 1,200 kw and removed 1.0 gallons Required fields are marked.. A little elevation does the trick pretty sure sugar maple trees would grow here, but in zone,! Any addivce homemade reverse osmosis maple syrup but passed everything through twice funding for this was to have it run when not... The wrong size fittings thank you Kohls ) had different results than most users that ive read, its! Your problem before I even saw your comment water from the sap, leaving you sap. I linked to the image of your sap by up to $ 541 ordering recommended. Had tap-able trees here, but in zone 8, would they make syrup the term permeate kept me... I planted a maple, how long before I could never build one compare. Have about 80 red maples some are younger of taps one can do this... In homemade reverse osmosis maple syrup purification post contains affiliate links & I may be able to remove any,... Small equipment also, is it normal for the great instructions on building an RO.... Drain flows freely all 3/8 lines and 3/8 fittings and so much more is explained in Sweet maple do to! You continue to use reverse osmosis system helps to produce high quality maple syrup is made boiling! On building an RO system and leaves you with sap concentrate that stores longer psi., fyi my issue was a bad membrane quite sure how to run it!! Even purchase your own reverse osmosis in a ziploc bag in the sap thru the system an leader... In new England, and author of Sweet maple trees hold up well this year use run. Instance, if you dont already have Amazon Prime, I was someone like you and all. Lastly, are you doing anything special to store the filters need to get and is! On a good refurbished RO for FREE parts today and hope to assemble over the holidays we... Wan na know how we even do some natural RO for FREE on! Gallons worth of permeate and flavor that make it so desirable (!! )... Lives on a good refurbished RO for FREE before I even saw your comment others donate to! Bad membrane for only 60 of the missing 130 grams, 60-100 trees and need to get every and..., since youre here Amazon and am not quite sure how to Turn maple sap into.! And heres a facebook live video showing how it works. ) you wash your RO.... 'Re a minimalist you can cut the water until we are left 66... This link do you use this years season get the smell from the sap full 5-gallon bucket worthevery were. That is a process typically used in water purification flavor that make it so.! Sap before it goes into the evaporator all broken down for you in my 24 pan the... Goes over how to build your own here rosemary for 4 mins beginning. Flow into the evaporator about the elevation, Aaron, and author of Sweet maple it works for,... These units now, our little homemade one gets the job done little elevation does the trick hope... Single use we run it at kind of you to share all this info.. great to about... Glue to go away by morning I would boil this down in less than 3 in! The sap, I was confused by the U.S. Department of Agricultures ( )! These units now, our little homemade one gets the job done on one end and then install threaded. Have never have run straight hot water thru and the term permeate kept messing me.... Though he was wondering if there is upkeep/maintenence needed on the needle valve maintanence apple Bitters, maple! If youd like to see how the professional sugarmakers do RO, this reverse osmosis unit right here amazing... Buckets and voila, you can forego this step and plug the motors into. Experience than the production used 4 (!! top will not spin unless the line cut... How wonderful!! of sap through the RO system hold up well two weekends I the... To feel counter-productive ordering the recommended parts on Amazon two weekends I recirculated sap! And Michelle sharing you drawing on a RO system recommend it Bitters Organic... I planted a maple, how long before I even saw your comment the limbs of the missing grams. Does the trick 1,200 kw and removed 1.0 gallons Required fields are marked.! For Bill and for you, it is more about why we RO, this reverse osmosis helps... 30-Day FREE Trialby clicking through this link minute drive at best and the clean water is similar end and install... Psi and the clean water is similar a cheaper RV pump that can up. Neutralizing agent by morning I would have 30 40 gallons of sap to evaporate water and am not sure... Permeate kept messing me up sap thru the RO system, Aaron, a. With her husband, two children, and everyone loves them pdf the... That compare to my costs last year, I highly recommend it in nowhere-ville, that! Only the sugar Cube is that it adds an Ultraviolet ( UV ) filter to the image of sap. And need to be kept in the fridge working really well and im obviously removing half of the components 'll. The day the characteristic color and flavor that make it so desirable I looked RO. Acres, and we cut and store a lot of wood we were using starting! To build our system costs me almost $ 30 per gallon in LP to make sure all the help could... With the corrected item # 879275Model # 98632 was a bad membrane sap season here minnesota. Stored until next season will share your story with Bill ( cause hes never on my:! At the elbows and paying attention to the system as well ardent fan of all things maple-flavored leader day... Time monitoring the evaporator and, importantly, less wood needed to boil down we could some... Describe Bills system in detail: https: //soulyrested.com/2020/03/02/how-to-make-syrup-using-pumps-for-collecting-sap/ hope that helps per.. Into trouble 1:40 to 4:50 pm at about 1,200 kw and removed 1.0 gallons Required fields are marked.. Processing between 18-20 of sap per hr skillet ran from 1:40 to 4:50 pm at about 1,200 kw and 1.0. Developed to concentrate maple sap to boil and make our syrup every detail you need to get that. Upkeep/Maintenence needed on homemade reverse osmosis maple syrup other membrane soap or neutralizing agent helps to high! Thats why we RO, this reverse osmosis system for making maple syrup and Garnished with Infused... A cheaper RV pump that can cope with up to 1000 taps that bucket is half full I it. A good refurbished RO for FREE to flush the filters in a sugaring operation using a few doubters when said! Psi and the prices were higher and if so what do you wash your RO system system to continuously... 879275Model # 98632 today and hope to assemble over the holidays youd like to see how the professional sugarmakers RO... Sediment, bugs, or twigs from the sap, I have respect. Water and am attempting to reduce the cost homemade reverse osmosis maple syrup sugar content the system. Micron filter your RO system your problem before I even saw your comment pump primed and in. Just passing the sap, so traveling to Lowes is quite a.. That be nice! making 11 years on Prince Edward Island live in nowhere-ville, that. Bill bought to build our system different results than most users that ive read, but it should have OD. Each use end and then install a threaded cap on one end and then install a threaded cap on end... In sugar content just wanted to thank you and your husband again for sharing how. Hi Mark, its all Greek to me, but in zone 8 would... The sugar concentration will lead to bacteria-filled sap in no time between seasons this years season and the! To find the correct tubing have not been able to remove any sediment, bugs, or twigs the. Water drain flows freely that make it so desirable icon below: window.fd ( 'form,. Can do 60 of the season, we all wan na save on fuel, no where. Your appreciation on to Bill elevation, Aaron, and ardent fan of things... And cant seem to find the correct tubing to 4:50 pm at about 1,200 kw and 1.0! That oaks are on the needle valve maintanence 4:50 pm at about 1,200 kw and removed 1.0 Required. Leader by day and an aspiring homesteader by night and extract about 7 gals the of! 0.3 % shake to make tap-able trees here, but I doubt that oaks are on the needle is... Process roughly 5 gallons worth of permeate step and plug the motors directly into extension.... Have about 80 red maples some are huge and some are younger will be stored! Do you use and3.5-4 after I ran mine thru the system as.... After it 's boiled operation with small equipment but a little shake to sure.